Page 4 of 4 FirstFirst ... 234
Results 31 to 39 of 39

Thread: 1995 Corrado VR6 Breaking VW MS VSR..., LSD, H&R coilovers, Big Valve Hd, Shrick cam

  1. #31
    ⋆⋆ CF Member ⋆⋆ easypops's Avatar
    Join Date
    13th July 2006
    Quote Originally Posted by Keyo View Post
    Just trying to get my head round what caused this poor chaps fire, when he says HVAC is that the air conditioning ?
    Can anyone speculayte in laymans temrs what happened and about diconnecting the battery ? Cheers.
    I have this car, as far as I’m aware, the fire broke out at the heater fan, it’s certainly the most melted part. The fire went all the way behind the dash as it’s quite warped. Electrical fire, so disconnection of the battery seems the sensible thing to try to do, which is easy to say after the event
    95 Classic Green Storm
    95 Flash Red VR6

    For those who understand, no explanation is needed.
    For those who do not understand, no explanation is possible

  2. #32
    Enthusiast Keyo's Avatar
    Join Date
    16th December 2018
    West Midlands
    Thanks for the reply.
    Would you disconnet the positive/red cable first in such an incident ?
    I wonder why one of the fuses didnt prevent this. I have an interest in this because I have purchased a VR6 a couple of months back and I noticed there was three different reciepts over two years detailing repair (not new) to heater resistor pack and also new heater motor, at present no 2 setting is not working on fan and also only hot air blowing windscreen and cold heat in all other direction settings, also for some reason cant move the air direction switch all the way up to windscreen screen , so having a bit of a mare ha

  3. #33
    ⋆⋆ CF Member ⋆⋆
    Join Date
    24th December 2008
    Crewe Cheshire
    Always negative off first, always negative connected last.

  4. #34
    CF-oholic! seanl82's Avatar
    Join Date
    1st September 2011
    North Devon
    The heater resistor is a common failure and gives symptoms of the heater only working on setting 4. The position of the fan and the inlet duct for it in the scuttle panel area means when the seal breaks down, it allows rain water in. This is likely to be the reason it cought on fire, as either it arced on the electrical components or as you may have had, just dried out the bearing on the fan causing it to become noisy and necessitating replacement. The other problem you have is that the direction flap is covered in foam which should direct warm/cold air to where it's set, but if the foam is broken you'll get air to your dash vents regardless. Finally, the direction dial is also a common problem as the Bowden cables attached from the dial to the airbox become stiff, so end up being forced and either break the teeth on the gearing, jump teeth, or break the mounting points for the cables. Heater matrix is weak and can block so you'll only get warm or cold air, or they'll rupture and spill boiling hot coolant into your foot well. Early signs are fogging of the windscreen. All common problems (except the fire which is rare and extreme) unfortunately.
    95 Classic Green VR6 - Jetex Cat Back|BMC CDA|VT mounts|Bilstein B12s|288mm front brakes|Mk4 Rears|Braided hoses|Daves16v shortshifter|Lupo wipers|Uprated headlight loom|
    CCGB #3982

  5. #35
    Enthusiast Keyo's Avatar
    Join Date
    16th December 2018
    West Midlands
    Thanks for detailed reply.

    The Heater Matrix was fixed in the last 2 years it says on receipt sent off too specialist for repair (not sure why they didnt buy a new one when there are loads on ebay ??????) It cost £650 there abouts mostly for labour I guess. .

    The Heater resistor pack had x 3 repairs over 2 years not sure why they didnt buy a new Resitor pack are they unavailable????

    My blower speed control is not working on 2 , 4 is fine so god knows.

    Looks like the hardest thing to fix is the bowden cable .

  6. #36
    Resistor pack doesn't usually go, it's usually just the thermal fuse on it that goes from fatigue. Replace the thermal fuse (carefully) and you're good. I replaced the heater fan on mine too as it started failing, became incredibly stiff.
    As for the fuse .. yeah but it's running on a 10A which is enough to make something pretty hot in the first place, and so many people react to a fuse blowing by putting in a higher rated one that used cars are a bit of a minefield when they've been owned by a tinkerer ..
    [ WARNING: the above message may contain irony, sarcasm and outright lies. ]

    ** Every time you think about sex, another Corrado gets written off. **

  7. #37
    ⋆⋆ CF Donator ⋆⋆ voo51's Avatar
    Join Date
    14th October 2007
    So sorry about your loss.

    Do you have a corrado script rear badge in great condition available?

  8. #38
    ⋆⋆ CF Member ⋆⋆ Storm Warning's Avatar
    Join Date
    16th January 2003
    East Mids
    Gutted for you :-(
    Have any of the parts sold now?
    I would be interested in:

    VW MS VSR with all the kit.
    Big valve head
    Wavetrac diff
    Tubular fabricated exhaust manifold
    Decat Miltek full stainless system
    Lightened crank pulley
    Vibratechnics Engine mount(s)
    Eibach ARB front

    Have any Pics... Detail on condition/mileage and price, cheers.
    My Storm HERE | 17" BBS RCs | Aero Wipers | BMC CDA | 19 Row Mocal | KWs | 312 Fronts | 263 cams | EVO Featured
    AM V12V | SQ5 | Caterham R460ish Superlight Race | Clio 197 Race | Series 1 Landy | Corrado VR6 VW Cup to be |

  9. #39
    ⋆⋆ CF Member ⋆⋆
    Join Date
    24th December 2008
    Crewe Cheshire
    This was bought by 2 forum members and parts split between themselves, OP no longer has anything from this car.

    Needs the thread locking?

Similar Threads

  1. 1995 Flash red Corrado breaking
    By Dubstar81 in forum Cars for Breaking
    Replies: 3
    Last Post: 22nd May 2017, 4:18 PM
  2. 1995 (M Reg) Corrado VR6 Breaking - Updated with Pictures
    By P3rks in forum Cars for Breaking
    Replies: 159
    Last Post: 11th March 2015, 9:58 AM
  3. Breaking Black non sunroof 1995 Corrado L041 parts pag 1
    By voo51 in forum Cars for Breaking
    Replies: 89
    Last Post: 23rd August 2012, 3:53 PM
  4. Breaking 1995 Corrado VR6 - 117k, Full Black Leather
    By Purple Tom in forum Cars for Breaking
    Replies: 264
    Last Post: 30th October 2011, 11:03 PM


Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
About us
We are the world's largest community for VW's Super Coupé! Be it 8v, 16v, G60 or VR6 (or maybe something else!), everybody's welcome! If this is your first visit, be sure to click register and fill out your details before you can post.
Help us
This site is run on donations.
Please help keep the forum alive!
Follow us
advertising & sponsorship
Are you a company looking for advertising that could benefits our users? For site & forum sponsorship, please see our dedicated microsite here.