Wayne2015 10 Posted March 31, 2015 Lol Looks like that was already answered. Yup! But thanks - so maybe no need to replace sunroof seal then! But, it did SOAKED the interior when I used a hose pipe to rinse car - so will need to look at the drains at some point ... Quote Share this post Link to post Share on other sites
Chuggs1 10 Posted March 31, 2015 Yeah more than likely drain holes are blocked Quote Share this post Link to post Share on other sites
g0ldf1ng3r 13 Posted March 31, 2015 Done! :) No more scraping noise! :dance: 1 down more to go ;) Quote Share this post Link to post Share on other sites
g0ldf1ng3r 13 Posted March 31, 2015 Found this awesome headliner removal steps :thumb right: I want to give it a go too (check sunroof leak, aerial leak, sort any rust too :)) http://www.corrado-club.ca/forum/viewtopic.php?t=9258 nice find wayne printed & stored with my other how to's lol Quote Share this post Link to post Share on other sites
Wayne2015 10 Posted March 31, 2015 Yeah more than likely drain holes are blocked Can I just check... Do I need to remove front / back bumpers AND wheel arches to get to the 4 drain outlets? Quote Share this post Link to post Share on other sites
Wayne2015 10 Posted March 31, 2015 1 down more to go ;) :lol: Yup Quote Share this post Link to post Share on other sites
MZpog 10 Posted March 31, 2015 Headliner removal is/was pretty easy, but I wouldn't try it alone as it's easy to bend/break it. Quote Share this post Link to post Share on other sites
Wayne2015 10 Posted March 31, 2015 nice find wayne printed & stored with my other how to's lol No worries, bud 8) I removed mine and find the following to add: That link very very good step by step removal of headliner. But, Be warn that its very very tight to pull out headliner. So, I recommend : 1. Remove as much trim as possible (or at lease loosen up)!!! 2. Prepare to get the inside covered in debris/old foam 3. Prepare to warp (of even crease/snap sponge headliner) 4. U need TWO people when pulling out the headliner (one to pull the other to keep bending the trims!) 5. Headliner needs new foam strips to replace on the topside (either they old or ripped out when sliding out :eek:) 6. Think about HOW to slot headliner back in :shocked!: But, this is just my experience :lol: Quote Share this post Link to post Share on other sites
Wayne2015 10 Posted March 31, 2015 Headliner removal is/was pretty easy, but I wouldn't try it alone as it's easy to bend/break it. Totally agree! I think did mine within 30mins...but at the end did struggle and got my son to sit inside to bend the trims more... Quote Share this post Link to post Share on other sites
Dox 22 Posted March 31, 2015 Can the sunroof drains be cleared by blowing through them with an air line? Or use something like the outer brake cable off a push bike and push the accumulated debris through? Quote Share this post Link to post Share on other sites
Wayne2015 10 Posted March 31, 2015 Can the sunroof drains be cleared by blowing through them with an air line? Or use something like the outer brake cable off a push bike and push the accumulated debris through? Certainly worth a go! But I like to do things thorough and take things apart! I did it on my Honda Prelude - but do NOT want to do it again! :eek: Not on the same car anyway! Balancing the rear bumper on my thighs whilst trying to slot into the bolts holes and bolt on is NO FUN - especially when it scrapes the wing paintwork as well! :shocked!: Quote Share this post Link to post Share on other sites
Dox 22 Posted March 31, 2015 Certainly worth a go! But I like to do things thorough and take things apart! I did it on my Honda Prelude - but do NOT want to do it again! :eek: Not on the same car anyway! Balancing the rear bumper on my thighs whilst trying to slot into the bolts holes and bolt on is NO FUN - especially when it scrapes the wing paintwork as well! :shocked!: Use masking tape on all edges of panels that may touch when removing and refitting painted panels Quote Share this post Link to post Share on other sites
g0ldf1ng3r 13 Posted March 31, 2015 Can I just check... Do I need to remove front / back bumpers AND wheel arches to get to the 4 drain outlets? no need to remove anything wayne open sunroof on slide fully fill a bottle up with water, 500ml with a nozzle helps in each of the four corners, one at a time m8, pour a little water into the channel & then check if it comes out under the car from the respective corner IE if you pour water into the front left drain it should end up coming out from under the front left wing if you dont see any water making it to the ground the channel may be blocked - a good squirt with an airline should budge the blockage IF you find a blocked one it might be worth checking if water is getting into the cabin or overflowing the channel on the sunroof cartridge i believe it is worth giving each drain hole a good blow out with an air line just anyway as a just in case ;) Quote Share this post Link to post Share on other sites
Wayne2015 10 Posted March 31, 2015 Use masking tape on all edges of panels that may touch when removing and refitting painted panels Believe me - i will need to go thru rolls n rolls of tape! :lol: Still it was good learning experience :thumb right: Quote Share this post Link to post Share on other sites
Wayne2015 10 Posted March 31, 2015 no need to remove anything wayne open sunroof on slide fully fill a bottle up with water, 500ml with a nozzle helps in each of the four corners, one at a time m8, pour a little water into the channel & then check if it comes out under the car from the respective corner IE if you pour water into the front left drain it should end up coming out from under the front left wing if you dont see any water making it to the ground the channel may be blocked - a good squirt with an airline should budge the blockage IF you find a blocked one it might be worth checking if water is getting into the cabin or overflowing the channel on the sunroof cartridge i believe it is worth giving each drain hole a good blow out with an air line just anyway as a just in case ;) Cheers bud I don't have an airline :( Nor justify buying one :( Actually are airline cheap? What other uses are they for? Quote Share this post Link to post Share on other sites
Dox 22 Posted March 31, 2015 Cheers bud I don't have an airline :( Nor justify buying one :( Actually are airline cheap? What other uses are they for? Improvise, a tyre inflator with the airbed nozzle fitted, gaffer taped to a length of dowel if needed. Quote Share this post Link to post Share on other sites
Chuggs1 10 Posted March 31, 2015 Could you get away with a bike pump if you could get a reasonable seal and then one or two quick pump could blow our any debri??? Quote Share this post Link to post Share on other sites
Jim Bowen 1 Posted March 31, 2015 Could use one of them air dusters for pc's etc Quote Share this post Link to post Share on other sites
Wayne2015 10 Posted March 31, 2015 Cheers guys Dox - I do have a tyre inflator :thumb right: Chuggs - nope! Jim - they powerful enough? Quote Share this post Link to post Share on other sites
Chuggs1 10 Posted March 31, 2015 Cheers guys Dox - I do have a tyre inflator :thumb right: Chuggs - nope! Jim - they powerful enough? I don't know - I think its a yes - dependant on wrist action!!!! Lol! Quote Share this post Link to post Share on other sites
Wayne2015 10 Posted March 31, 2015 I don't know - I think its a yes - dependant on wrist action!!!! Lol! I do NOT want to tell work I got RSI from a PC air duster! :( :lol: Quote Share this post Link to post Share on other sites
g0ldf1ng3r 13 Posted March 31, 2015 I do NOT want to tell work I got RSI from a PC air duster! :( :lol: no they dont have enough pressure really wayne - if the garage is having the car again ask them to give the roof drains a blow out. it is a 30 second job once sunroof is open so they shouldnt charge you BUT you can check if you even need to blow them out first by testing with water as i described ;) PS an airline uses an air compressor which tend to be bulky & costly Quote Share this post Link to post Share on other sites
g0ldf1ng3r 13 Posted March 31, 2015 I do NOT want to tell work I got RSI from a PC air duster! :( :lol: m8 the only RSI you will be getting is from all the typing on this forum!!! PMSL Quote Share this post Link to post Share on other sites
Wayne2015 10 Posted March 31, 2015 no they dont have enough pressure really wayne - if the garage is having the car again ask them to give the roof drains a blow out. it is a 30 second job once sunroof is open so they shouldnt charge you BUT you can check if you even need to blow them out first by testing with water as i described ;) PS an airline uses an air compressor which tend to be bulky & costly No no no! It means I need to wind the sunroof back manually by Allen key.. And should the sunroof get stuck opened and the heaven open up.... I will try it when the C is safely parked in my garage at home! Quote Share this post Link to post Share on other sites
Wayne2015 10 Posted March 31, 2015 m8 the only RSI you will be getting is from all the typing on this forum!!! PMSL :lol: I am on leave ;) Have to use up my leave in March or lose it! :eek: Quote Share this post Link to post Share on other sites
